Education Zone

The Tri-Zone Brushing Boots have undergone independent testing with Dr David Marlin to establish exactly how breathable they are, and how this compares to other similar boots on the market. The testing method was designed to measure the amount of moisture escaped from the boot. This was performed in a controlled laboratory environment to eliminate as many variables as possible that can be experienced when testing on a live horse. The Testing Method: A model of a horse’s leg had several holes drilled into it around the tendon area and cannon bone where a boot would usually sit. An inlet for steam was attached to the base of the leg and this was all housed within an acrylic box fitted with temperature and humidity sensors. There were also 2 fans fitted within the box (one at the top and one at the bottom) to ensure air movement. The leg was fitted with the breathable brushing boots, and duct tape applied at the top and bottom to create a good seal. Steam was pumped into the model leg and the rate at which the moisture passed through from the inside of the model leg, through the holes and the boot into the acrylic box was recorded. Figure 1. A = temperature and humidity sensor; B = fan; C = steam inlet; D = plastic leg; E = drain; F = steam generator. This method was then repeated for various types of similar brushing boots so a comparison could be made. The test was also carried out with no boot on the model leg so a ‘best case scenario’ could be compared back to. Results If the test with no boot on the leg allowed 100% moisture release from the leg, all other readings can be compared back to this. The New Breathable Brushing Boot allowed 87% moisture to escape through the boot. The average amount of moisture released from the other 11 boots that were tested was 48%. In conclusion the new Breathable Brushing boot allows 80% more moisture release than other similar boots that were tested. 87/48 = 1.8 = 80%  

Should horse boots be considered as safety equipment? You must have heard of the phrase ‘no hoof, no horse’? Well, this could ring true for a number of other things too, such as their lower legs – one of the most common areas to be damaged or suffer from injury. As riders, we protect our most vital areas (head and torso) with riding hats, body protectors and more recently air jackets. Rider protective equipment is subjected to extensive testing to meet standards and regulations. We believe that protective boots for your horse’s legs should undergo a similar testing process, which is why we send our Tri-Zone Boots to be tested by an independent laboratory, before they go near a horses’ leg. So what features should you be looking for in a pair of boots? The primary function of a boot is protection. There is little evidence to suggest that boots can provide support, although boots are commonly sought out for this use too. The problem is, you can’t tell how protective a boot is, just by simply looking at it. The only way to tell if a boot is protective enough is for it to be tested under controlled conditions, to forces that we can replicate (such as when a horse hits a fence, over reaches or strikes itself with another limb). There are some other factors to be considered too, which can potentially hinder performance or increase the risk of injury. So what other features should be looked at? Flexibility or Stiffness Rigid or inflexible boots have the potential to restrict joint movement, which in return can affect stride characteristics and performance, and possibly even compromise tendon function. Boots need to allow as much freedom of movement as possible while still providing enough protection. Weight and Ability to Hold Water The more weight added to a horse's leg, the more effort the horse will have to use to move that weight - resulting in unnecessary effort and wear and tear. It can also change the way the horse moves too. If the horse is likely to go through water, taking into consideration how much water will be held by the boot, will impact the weight on the horses' leg too. Breathability and Insulation Tendons naturally get warmer through the process of loading and unloading during exercise. The ideal boot would allow this heat to escape, instead of insulating it. It's a fairly well known concept, but also backed by research, that tendons are particularly sensitive to heat, and it can result in tendon damage and/or inflammation. Fit of the Boot The bot should of course be comfortable for the horse too - we know when we wear ill-fitting boots they can not only rub, but also cause you to change the way you move to try avoid the pressure the boot is putting on a certain area. A correct fit will also ensure debris and surface does not get underneath the boot to cause any irritation. Lastly, over-tightening of boots and/or bandages can cause restriction and rubbing too. Our Unique 3-Phase Testing Process Tri-Zone boots go through a 3-phase testing process, giving you the confidence that you are choosing the best leg protection for your horse. Materials are carefully selected to provide maximum protection but without being bulky, heavy and not make your horses legs hot and sweaty. Each individual layer in the Tri-Zone boot is researched and sourced for their advanced technical properties and tested in an independent laboratory before it goes anywhere near a horse's leg! FIND OUT MORE

Headcollars are one of the most used pieces of horse equipment. In fact, 88% of owners use a horse headcollar every day*. As riders, we have safety equipment to protect ourselves, such as boots, hats, and body protectors. This is obviously to prevent injury or the severity of injury in the event of an accident. But is there a need for our horse headcollars to be safe too? We designed our Stellar Headcollar after researching headcollar accidents, read on to find out what we found. Why is it important that horse headcollars are safe? We’ve already established that headcollars are used frequently. But when looking into the research around headcollars, there didn’t seem to be any. Even ‘safe’ headcollars seemed to have no testing (from what is publicly available to view). First, is there a need for safety? Are headcollars potentially causing injury to horses? Dr David Marlin undertook a survey of 5615 horse owners to find out*. The results showed the following: Almost 1 in 3 horses were injured as a result of a headcollar related incident. More than 1 in 7 people were injured as a result of a headcollar related incident. 167 horses were fatally injured as a result of a headcollar. These incidents happened during various points of general horse handling, with most of them occurring when horses were tied up. If you think about it… Most horse owners tie their horses up daily. Then when we travel or compete, horses can be tied up even more frequently. Of course, there are always other accidents that can happen, especially if your horse is turned out in a headcollar. We all know of the freak accidents too, where horses get their headcollars attached to gates, or stable doors. In summary, these survey results certainly demonstrate the need for headcollar safety. While some horse owners may think that their horse doesn’t need a safe headcollar, it follows the same principle as our own riding hats. You may only fall off once every few years – but your hat is there to protect you when you do. Your horse may have never had an accident involving a headcollar. But a safe headcollar will be there to help them if they do. How do you know a horse headcollar is safe? The first step to find out if a headcollar is safe is to look at what could potentially cause injury. There is likely to be two reasons: The force placed on the horses’ head from the headcollar during an incident. The horses panic, if they are restricted, could cause them to fall or thrash around blindly. Survey Results These reasons are backed up by the survey results too, showing that horses sustained various injuries from headcollars*, including: Bruising Cuts Fractures Like a hat, body protector or pair of boots for your horse, the only way to know if a headcollar is safe is to test it. For headcollars, determining its safety is going to be related to when it releases. If it doesn’t release, this could cause severe injury not only to the horses’ head and surrounding structures, but also cause the horse to panic and potentially do further damage. Headcollar Testing Dr David Marlin tested a range of typical headcollars to find out their release points. The results were surprising, with some headcollars being able to suspend a horse’s entire body weight before releasing or breaking. Look at the below diagram for example. This is a representation of the amount of weight it takes for these headcollars to release shown in hay bales. It doesn’t take much imagination to understand how much weight goes onto your horse’s head when they are struggling to get free. On the other end of the scale there are headcollars which released far too easily. This could mean that they are not suitable to handle your horse with for day-to-day management. This too could pose a safety risk if they were to release while leading or unnecessarily.  What is the solution? For your horse’s safety, in the event they need to get free, using a headcollar which releases at the lowest amount of force will always be the safest option. This, however, is not a practical solution. We need to be able to tie up our horses and have the headcollar be able to withstand some pressure. Or lead and have the headcollar withstand a horse pulling or perhaps feeling fresh. Therefore, the ideal headcollar will provide a balance – so that you can handle your horse safely, but it will also release if you horse gets into real trouble. Without testing, there’s no way to measure this. So, using a headcollar with testing behind it can give you confidence that if your horse needs it, it’s ready to release. The Stellar Headcollar The Stellar Headcollar was designed because of this research and testing. It can be used for everything from tying up, leading, travelling and even as a field safe headcollar too. We not only wanted to create a long lasting, comfortable and smart headcollar, but we wanted one you could trust too. Horses as we know are unpredictable, so having a headcollar there for when you need it could save your horse from serious injury.  References; An online survey of equestrian headcollar use and safety - Marlin - 2022 - Equine Veterinary Education - Wiley Online Library Opening forces or failure of commercially available equine headcollars and other safety devices - David J Marlin, Kirstie Pickles, Roberta Ferro de Godoy, Jane M Williams, 2021 (sagepub.com)